1991 Subaru Legacy Sport Sedan
1 of 207 built
Factory Specifications:
2.2L Horizontally Opposed, Turbocharged 4-Cylinder (EJ22T)
4-Spd. Automatic Transmission
All Wheel Drive
160 Horsepower & 181 ft/lb Torque
Weight: 3140 lbs.
Accessories & Modifications:
|
Appearance |
PERFORMANCE | Convenience |
| 2000 Impreza 2.5RS Wheels | Green High-Flow Filter | Aiwa AM/FM CD Stereo |
| 2002 Impreza WRX Front Strut Mounts | ||
| 1999 Impreza 2.5RS Springs | ||
| KYB-GR2 Struts | ||
| 2002 Impreza WRX Exhaust Manifold / Header |
Project Timeline:
|
Date |
Update |
| 11/11/2003 | Picked up car, towed to Mastro Subaru for evaluation |
| 11/12/2003 | Bought & installed new Battery |
| 11/15/2003 | 1st Trip to the U-Pull, pulled: new wiper arms, trunk latch, trunk light & misc. trim. |
| 11/15/2003 | Purchased new wiper blades, installed arms, blades & new trunk latch. |
| 11/18/2003 | Mastro completed evaluation, car needs; new tranny, tranny mount, P/S pump, RT CV boot, oil pan, rear susp. bushings. |
| 11/19/2003 | Made arrangements to have Mastro replace tranny & tranny mount, parts have been ordered. |
| 11/21/2003 | 2nd Trip to U-Pull, pulled: lower dash trim, P/S pump, alternator, stereo wiring harness & misc. trim. |
| 11/21/2003 | Went to Mastro and installed P/S pump, alternator, Green Filter and fixed some misc. issues. (Bought P/S fluid & vac. line) |
| 11/22/2003 | 3rd trip to U-Pull, pulled Misc. under-hood brackets, fluid caps & interior trim pieces |
| 11/22/2003 | Picked up from AutoZone: 2 wheel studs, oil filter, PCV, fuel filter & a brass oil drain plug washer. |
| 11/24/2003 | Located a good used oil pan! |
| 11/25/2003 | Located a good interior leather set (Steering Wheel, Auto Shifter & Parking Brake Handle) |
| 11/28/2003 | Picked up new Air box to turbo boot, NGK Spark plugs and engine cover grommets |
| 11/28/2003 | Corrected short in stereo wiring (causing battery to drain!), fixed drivers door lock, installed intake boot & grommets |
| 11/29/2003 | Replaced 2 damaged wheel studs, Replaced damaged oil pan, Installed new front sway bar bushings, 1st Oil & Filter Change - 131,060 miles. |
| 11/30/2003 | Vacuumed & washed car, replaced PCV, plugs & fuel filter, caused and then fixed massive oil leak! Removed window tint. |
| 12/3/2003 | Purchased New Starter |
| 12/5/2003 | New transmission & starter was installed at Mastro!! Thanks Snowman! :) |
| 12/6/2003 | Picked up parts I had ordered, found several more items that need to be replaced, submitted large parts order. |
| 12/8/2003 | Picked up car from Mastro; New tranny, tranny mounts, external filter & misc. parts and pieces and starter all have been installed. |
| 12/8/2003 | Installed 2000 2.5RS Wheels & tires, installed new stereo & 1.5" DIN pocket |
| 12/10/2003 | Picked up oil cooler gasket, coolant lines, PCV hose, etc from Mastro, A/C started working on it's own! |
| 12/10/2003 | Picked up front half-shaft (axle) from AutoZone |
| 12/11/2003 | Ordered KYB-GR2 Struts and a full Rear Suspension Bushings Set, Removed "yellowing" from headlights |
| 12/11/2003 | Installed new steering wheel, scrubbed grime from front headrests |
| 12/13/2003 | Installed front right axle (half-shaft), drained and replaced rear differential fluid, installed new parking brake handle and shifter handle |
| 12/16/2003 | WRX stock exhaust manifold is on the way thanks to a generous donation from the JMS Crew! Thanks Ben & Shaun!! |
| 12/17/2003 | Rear suspension bushings, WRX header and 2.5RS springs arrived. |
| 12/19/2003 | Received Upper Spring Perches |
| 12/20/2003 | Removed & Resealed Sunroof, went to Cophers, picked up misc. nuts, bolts & clips, got rear taillight center piece, timing cover, etc. |
| 12/21/2003 | Installed rear center reflector piece and ,successfully transferred "Legacy Turbo" & "AWD/ABS" badges! Repaired all burnt out interior bulbs. |
| 12/26/2003 | Picked up WRX header gaskets and nuts & bolts from Mastro, Installed front GR2 Struts, WRX Strut Mounts & 2.5RS springs |
| 12/26/2003 | U-Pull-It Gold mine! Pulled: Rio Red Drivers fender, Drivers side speaker cover, pass. side sun visor, left headlight, center console |
| 12/27/2003 | Went back to U-Pull, got rear upper strut mounts, and a few more interior trim pieces, fixed both front door speaker covers. |
| 12/27/2003 | Installed rear GR2 Struts & RS springs, adjusted parking brake, bled brakes, installed new 12v Accessory plug, center console, sun visor. |
| 1/1/2004 | Installed new oil cooler seal, and replaced all hoses & lines between the water pump > oil cooler > block. Installed new plug wires. |
| 1/1/2004 | Installed WRX header w/all new gaskets, replaced block to PCV lines & hoses, replaced many vacuum hoses. Degreased motor. |
| 1/4/2003 | Installed new rear lateral link bushings, inner & outer, replaced sway bar bushings & end links. Discovered torn drivers side rear CV boot. |
| 1/7/2004 | Mastro Subaru replaced: Cam Seals, Timing Belt, radiator hose, water pump, resealed oil pump, tensioners, rear CV boot and 4-wheel alignment. |
| 1/12/2004 | Installed 2 more new PCV related hoses! |
| 1/13/2004 | Tightened loose chimney turbo bolt to stop rattling noise! |
| 1/17/2004 | Shampooed & Scrubbed Seats and carpet, scrubbed all interior plastics, replaced pass. side A pillar trim and pass. side headlight. |
| 1/25/2004 | Replaced A/C vent controller motor, Removed rear wing began to primer & sand for painting, 2nd Oil & Filter Change - 133,100 Miles |
| 1/26/2004 | Continued sanding & priming rear wing.... |
| 1/31/2004 | Properly re-attached the heat shield around the turbo & down-pipe |
| 2/1/2004 | Reinstalled rear wing! |
| 2/3/2004 | New Windshield was installed, picked up new front brake rotors & pads. |
| 2/4/2004 | Installed new front brake pads, shims, hardware, rotors and guide pin boots. Lubricated guide pins. |
| 2/10/2004 | Purchased and installed new power antennae mast, purchased used Canadian spec front seatbelts to eliminate the annoying automatic seatbelts! |
| 3/6/2004 | Obtained Ford Probe Intercooler...will see if it will work on the Legacy! :D |
| 3/7/2004 | 3rd Oil Change, 135,973 miles |
| 3/10/2004 | Determined Ford Probe Intercooler won't work, bought Saab 900 Intercooler off Ebay. |
| 3/12/2004 | Decided that 3 cars was one too many, with the '05 Legacy coming out one needs to go...selling this one. |
| 3/13/2004 | Replaced Inlet & Outlet Heater hoses, also replaced misc. coolant hoses around tank. Used all new OEM hoses & clamps. |
| 3/20/2004 | Had Valve Cover Gaskets replaced by Mastro Subaru |
| 4/4/2004 | Sold Car |
2002-2009 © Copyright Will Conklin, All images and content has been used with permission or is owned by Will Conklin. No part of this web page may be used without consent. This site is in no way affiliated with or endorsed by any automobile manufacturer. All Rights Reserved